Quick Answer: Is 15 Volts Too High For Alternator?

What happens if voltage is too high?

Voltage that is too high can cause premature failure of electrical and electronic components (e.g.

circuit boards) due to overheating.

The damage caused by overheating is cumulative and irreversible..

Is 15 volts too high?

Higher than 15 volts indicates a fault in the charging system’s voltage regulator or related circuits. If it’s substantially excessive, this can cause electrical system and/or battery damage. You mentioned your voltmeter runs at about 15 volts most of the time.

What causes an alternator to put out High Voltage?

If you are getting more than 2 volts above base voltage, most likely your alternator is over-charging the battery or the battery is faulty. Other potential problems are a faulty voltage regulator or a problem in the charging system wiring.

Is 14.7 volts too high?

Charging voltages over 14.7 volts can prematurely dry the battery by boiling out electrolyte, and increase risk of a battery hydrogen gas explosion. … Less than 14.3 would be a “weak” alternator or regulator. Much less than 14.2 at a fast idle is bad wiring, bad alternator or regulator, or a bad connection or fuse link.

What causes high charging voltage?

Charging voltage is too high means that the regulator is bad: It’s less common, but you may see that the charging voltage is too high, like over 15 volts. This means that the voltage regulator is stuck in the closed position.

What should voltage be at idle?

At idle, most charging systems will produce 13.8 to 14.3 volts with no lights or accessories on (although some may charge at a slightly higher voltage depending on temperature, engine RPM, type of battery, and the battery’s state of charge).

What is the highest amp alternator?

— Remy International Inc., manufacturer and distributor of Delco Remy brand heavy-duty starters and alternators, has released its most powerful and efficient alternator yet to the aftermarket. The Delco Remy 55SI has a durable brushless design and is rated at 420 amps at 12 volts and up to 275 amps at 24 volts.

Does an alternator charge all the time?

While the battery supplies the electricity needed for that initial spark, it only has enough power to get the car a few miles down the road, and that’s where the alternator comes in—it continually charges the car battery while the car is in motion while also simultaneously operating all the electronic components of the …

Why is my alternator putting out 17 volts?

The desired full charge voltage is 14.2 Volts. … 17 volts is just about max unregulated output on a 12 volt alternator so I would suspect that the voltage regulator is defective or somehow not working correctly. To put things in less dramatic terms.

How much voltage is too much from an alternator?

For some alternators, it’s normal to see as low as 13 volts. For some, a constant 13.6 volts is an indication of a problem. For others, it’s normal to see as high as 16 volts for long stretches.

What are the symptoms of an overcharging alternator?

Symptoms of Overcharging an AlternatorHigh Gauge Reading. An overcharging alternator will cause the voltmeter on the vehicle’s dash to read an overly high voltage that may or may not vary with engine speed. … Low Battery Electrolyte. … Burnt Bulbs. … Battery Heating. … Swollen Battery. … Seeping Battery.

Can an alternator be too powerful?

If you’re worried about a high amp alternator providing too much power to your ECU, or any other component in your electrical system, you don’t need to. The amperage rating on an alternator is basically just the amount of current that the unit is capable of putting out, not the amount it always puts out.

Can overcharging alternator kill battery?

Alternators that overcharge will typically produce excess voltage to the battery, making the battery case swell up, become very hot and lose its electrolyte through boiling. Improperly jump-starting the vehicle can send a surge through the battery that destroys one or more cells in the battery or shorts it out.